Electrolux 318201775 User Manual download pdf (Page 4)

30" GAS RANGE INSTALLATION INSTRUCTIONS

Shutoff Valve -

Open position

to appliance

to gas supply line

Figure 5

Use pipe-joint compound made for use with Natural and

LP/Propane gas to seal all gas connections. If flexible

connectors are used, be certain connectors are not kinked.

The supply line must be equipped with an approved

manual shutoff valve. This valve should be located in the

same room as the range and should be in a location that

allows ease of opening and closing. Do not block access

to the shutoff valve. The valve is for turning on or

shutting off gas to the appliance.

Once regulator is in place, open the shutoff valve in the

gas supply line. Wait a few minutes for gas to move

through the gas line.

Check for leaks. After connecting the range to the gas

supply, check the system for leaks with a manometer. If

a manometer is not available, turn on the gas supply and

use a liquid leak detector (or soap and water) at all

joints and connections to check for leaks. Leaks will be

indicated by bubbles appearing at the connections or

joints.

Assemble the flexible connector from the gas supply pipe

to the pressure regulator in the following order:

1. Manual shut-off valve (not supplied)

2. 1/2" nipple (not supplied)

3. 1/2" flare union adapter (not supplied)

4. Flexible connector (not supplied)

5. 1/2" flare union adapter (not supplied)

6. 1/2" nipple (not supplied)

7. Pressure regulator (supplied)

3. Gas Supply Installation

When shipped from the factory, this unit is designed to

operate on 4"(10,16 cm) water column (1.0 kPa) Natural

gas manifold pressure. A convertible pressure regulator is

connected to the range manifold and MUST be connected

in series with the gas supply line. The gas connector is

located as shown on figure 3. It is accessible from front of

the range.

For proper operation, the maximum inlet pressure to

the regulator should be no more than 14"(35,56 cm) of

water column pressure (3.5 kPa).

The inlet pressure to the regulator must be at least 1" (.25

kPa) greater than the regulator manifold pressure setting.

The regulator is set for 4"(10,16 cm) water column (1.0

kPa) Natural gas manifold pressure; the inlet pressure must

be at least 5"(12.60 cm) water column (1.25 kPa) Natural

gas. For LP/Propane gas, the regulator must be set for

10"(25,4 cm) water column (2.5 kPa) manifold pressure;

the inlet pressure must be at least 11"(27,9 cm) water

column (2.75 kPa).

The supply line should be equipped with an approved

shutoff valve (see Figure 4 and 5). This valve should be

located in the same room as the range and should be in a

location that allows ease of opening and closing. Do not

block access to the shutoff valve. The valve is for turning on

or shutting off gas to the appliance. Open the shutoff valve

in the gas supply line. Wait a few minutes for gas to move

through the gas line.

The gas supply between the shutoff valve and the regulator

may be connected by rigid piping or by CSA-approved

flexible metallic union-connected piping where local codes

permit use.

The gas supply piping can be through the side wall of the

right cabinet. The right side cabinet is an ideal location for

the main shutoff valve, if the range is installed within

cabinet storage space

Connection to Pressure Regulator

The regulator is already installed on the appliance.

Do not make the connection too tight.

The regulator is die cast. Overtightening may crack the

regulator resulting in a gas leak and possible fire or

explosion.

The gas supply line to the shutoff valve should be

1/2"(1,27 cm) or 3/4"(1.9 cm) solid pipe.

The user must know the location of the main shutoff

valve and have easy access to it.

When using flexible gas conduit on the range, allow

sufficient slack to pull the range outside the cutout for

cleaning or servicing.

NOTE: Do not allow the flexible conduit to get pinched

between the wall and the range.

All connections must be wrench-tightened

Figure 4

Flare

Union

Flare

Union

GAS FLOW

Manual

Shutoff

Valve

Pressure

Regulator

Off

Flexible

Connector

Access

Cap

Nipple Nipple

Suggested gas connection

1 2 3 4 5 6 7 8 9 ... 19 20

Comments to this Manuals

No comments

Electrolux 318201775 User Manual Page 4

Comments to this Manuals

Related products and manuals for Radio Electrolux 318201775